I would take a sample and send it to an oil testing company for analysis before anything else except perhaps changing the filter. What are the fluid capacities of 2007 chevy 2500 hd truck with a duramax diesel/allison trans.1st-oil filter . 0000012695 00000 n When the transfer case fluid was changed it mistakenly had the Auto Trak II fluid put in it. If true, then it may be a good thing as you are getting more of the old fluid out of the mechanism and more new fluid inside. For more instructions on adding fluid or oil to your truck, see your L5P Duramax owners manual. Shift the transmission to neutral (N) and shut down the engine. For a fluid change, it is between 75,000 to 150,000 miles or 3,000 hours of operating time. 0000013038 00000 n Torque converter: One stage- three element- polyphase. I really doubt the A/T fluid needs changing unless you see evidence of contamination in the fluid. 12.3 L. Without special equipment it is possible to replace only ATF in the AT pan because of the way automatic transmission in 2011 Chevrolet Silverado 2500 HD has been designed. YouTube Years: Standard Tow Rating: Max 5th Wheel Tow: GVWR: Payload: 2011-2014: 13,000 lbs: 17,500 lbs: The Allison Transynd fluid replacement schedule is 150,000 miles OR 4,000 hours OR 48 months whichever comes first for general specs. Houston, Tx 77040, Phone 713.466.9838 0000008692 00000 n If you want that capacity in liters, then you are looking at 28 liters for the deeper pan and 25 for the shallower or regular pan. I'm at 9qts. The chart below shows general L5P Duramax maintenance and service intervals. 0000008059 00000 n 2. (Helpful Guide), What Is Freightliner J1587 Code? As such, there is some "head room" in terms of power capacity. Allison Approved Fluids that are synthetic based offer improved viscosity that other fluids can't offer. If the fluid level is not within the HOT RUN band, add or drain fluid as needed to bring the fluid level within the HOT RUN band. Listed below are GMs recommended maintenance schedule for trucks that are driven under normal conditions. 386. We Have You Covered Extended Transmission Coverage (ETC) Harness the Power of Genuine TES 668 Transmission Fluid Your Fleet of Information Allison HUB Premium What are the fluid capacities for a 2004 Chevrolet 2500HD 6.6l Diesel? Make Kamil's day and share it with a buddy! Use them to guide the maintenance of your Allison transmission. There are almost 20 brands to choose from on the list on the first page. While our guide will give you the manufacturer's recommended fluid capacity for the L5P Duramax, you always need to check your dipsticks and tank levels. After replacing the transmission fluid or changing the filter(s), it is important to check the fluid level cold to determine if the transmission has a sufficient amount of fluid to be safely operated until a hot check can be performed. Do not mix types and brands of fluid, because of possible incompatibility. it may vary. So I called the local Chevy dealer who said 7.4 qts. Privacy Policy, Buy oils, filters and other consumables online, Output engine Torque Nm (lb-ft): 780 (575), Torque converter: One stage- three element- polyphase. The 6L90 transmission is a six-speed automatic that was introduced in the Chevy Silverado and GMC Sierra in 2007. . 19. The transmission fluid capacity for the 2005 Chevrolet Silverado 2500HD iS7.8 pints for the manual and 7.7 quarts for initial fill and 13.5 quarts for total fill for the 4-speed automatic and 7.4 quarts for initial and 12.7 quarts for total for the 5-speed automatic. This fluid option is the next generation and the upgrade over the TES 295 version that has been used by Allison successfully for 20 years. While our guide will give you the manufacturers recommended fluid capacity for the L5P Duramax, you always need to check your dipsticks and tank levels. Drain and fill 5 & 6 speed Allison 1000 & spin on 7.4 Quarts. Chevy Silverado 2500HD. Oil capacity is just one of many. Also, Allison has created a page of the best transmission fluids to use on their transmission. (Ford V10 Turbo Kit Options), What Sealant Can I Use On a TPO Roof? Take the time to do some research to make sure you know how to properly maintain this piece of vital equipment. They will also recommend a good transmission fluid brand for you to use. Marketing & Dealer Support, Unearthed Magazine . (Ford V10 Turbo Kit Options), What Sealant Can I Use On a TPO Roof? 6-Speed Allison Transmission: VIN Identification: (8th Digit of VIN) 8: Displacement: 403 Cubic Inches or 6.6 Liters: . If the fluid level is within the COLD RUN band, the transmission may be operated until the fluid is hot enough to perform a HOT RUN check. Only Allison Approved transmission fluids are formulated for the unique components of an Allison Automatic. Come join the discussion about duramax engines, performance, builds, modifications, classifieds, troubleshooting, maintenance, and more! On both web pages linked above, there is a lit of recommended brands you should be using. bit of problem buying too many trucks. Here is the link to those charts and you can use that link even if you have a 200, 3000, or 4000 series transmission. You should get 17 and 19 quarts inside the transmission depending on the fluid pan used for your particular model. When the valve sticks TCM detects that the pressure sensor doesn't change the status and sets the trouble code P0872- after that the gearbox switches to the failsafe mode. 0000594149 00000 n PTO mounting pads. 0000009049 00000 n Terms of Trade Total using two PTO's: 1595 Nm. Allison ensures that our high quality transmissions endure with Allison Approved transmission fluids. If they are honest, and not all mechanics are, then you should get the capacity plus information on good transmission fluid brands even if they are not famous. Allison Transmission TES 295 Approved Fluids are approved for use in Allison 1000 Series, 2000 Series, 3000 Series, 4000 Series and H 40/50 EP on-highway products.. Allison recommends that customers using TES 295 Approved Fluid consider Allison's newest fluid spec, TES 668 , for their next service.. To purchase an Allison approved fluid, use the Sales + Service Locator . 0000002369 00000 n Make sure to use the right fluid in your transmission as these modern pieces of equipment are more finely tuned than older cars and trucks transmissions. It will take about 30 - 90 minutes depends on your skill level and might save you up to $200 depends on the region you live in. 48RE - 14.5-16.5 Qt (14-16L) 45RFE/545RFE - 14.8-16.9 Qt (14-16L) 68RFE - 16.4-17.5 Qt (15.6-16.6L) 68RSC/AISIN - 13.74 Qts. 0000601811 00000 n Any figures we give here are approximations only. That situation usually arises when your RV, etc., has been sitting for a while. What we find interesting in both categories is that the brand name does not matter. The PPE deep transmission pan adds an extra four quarts of fluid capacity. The Allison 3000 may have to re-learn shift points after a fluid change. Allison 3000 Transmission Fluid Capacity. You can use any brand that makes and sells the TES 668. Includes standard integral damper which is operational in lockup. (Helpful Guide), What Is Freightliner J1587 Code? It is called TES 668. Watch how regular fluid changes with Allison Approved Fluids can help extend the life of your transmission. It is not going to be so much about the brand but the type of fluid you should use. Answered by GM Tech . (Data Link Troubleshooting), How Many Quarts Of Transmission Fluid Does An Allison 3000 Take?, Allison 3000 Transmission Fluid Capacity, How Often Should You Change The Allison 3000 Transmission Fluid?. Deviating from the schedule may not initially harm the transmission but eventually, it may harm it. Ten-bolt, 1 o'clock and 8 o'clock positions (as viewed from rear) PTO drive gear ratio. You can also visit our Fluid Capacity & Recommendations for the L5P resource to find out what type of fluid and oil you need. The recommended transmission fluid is the fully synthetic DEXRON ViATF automatic transmission fluid. That is what you have to be cautious about and if you have any questions just talk to your mechanic or refer to your owners manual. 6L90 Transmission Fluid Capacity. 2500 & 3500 Double Cab Short Bed: 29.4 Gallons . Allison Transmission 5000, 6000, 8000, 9000 SeriesOff-Highway Transmissions Commercial Electronic Controls 2 (CEC2) TS3353EN Troubleshooting Manual [PDF] 12Mb: Download: Allison Transmission DDEC IV Application and Installation Manual [PDF] 2.8Mb: Download: Allison Transmission HT, HTB, CLT, CLBT 700 Series Service Manual [PDF] 1.4Mb: Download Properties Of Advanced Automatic Transmission Fluid. Engine, Transmission, Front and Rear Differentials, and the Transfer Case. If the fluid level is not within the COLD RUN band, add or drain fluid as needed to adjust the fluid level to the middle of the COLD RUN band. Allison Approved synthetic fluids provide extended drain intervals and offer thermal and viscosity advantages over conventional petroleum based fluids, as well as other synthetic fluids. DEF Fluid Capacity: 5 Gallons: Cooling System Capacity: 25.4 quarts or 24 Liters: . This will depend on the type of fluid you are running in your transmission. Hello paige farrar: Depending on the transmission the fluid and capacity is as follows. With the engine idling, remove the dipstick from the tube and wipe it clean. Fax 713.466.9839 You also have to be concerned about power steering fluid, brake fluid, and also transmission fluid. What are the fluid capacities for a 2004 Chevrolet 2500HD 6.6l Diesel? There is a lot more to car care than you realize. Good maintenance habits help prevent costly repairs and they do not take up a lot of time. 0000007069 00000 n drive gear rating (continuous operation) Using one PTO: 930 Nm. The first is to check your owners manual to see what the manufacturer says. The synthetic fluid is designed for the big rigs that haul more tons of dirt, etc than a tank weighs. Park the vehicle on a flat, level surface. They work on these transmissions and know exactly what they need. Operate the engine at idle (500 to 800 rpm) until normal operating temperature is reached. You do have to be careful as the transmissions, etc, are designed with certain specs that can only be met with the right fluids. (6.5L) NOTE:Must add 2 additional quarts of Manual Transmission Fluid through the shifter after its filled to the factory fill plug. Marvin the Mechanic. They should have the specs for all the models they sell and tell you about different top fluid brands you should use. Operating a transmission with the fluid level higher or lower than recommended can result in transmission damage. Acceptable engine idle speed range (with transmission in drive): 500 - 820 rpm. (13L) NV5600 - 6.75 Qts. I use only high quality oils and fluids in my trucks. Allison 1000: 13/12.3: N/A: DEXRON III: DM, DVI: 05-08: Allison LCT 1000 (LW7) 13/12.3: 7.4/7: DEXRON VI: MLV: L5P Duramax Maintenance Schedule & Service Intervals. 0000001649 00000 n This option you should not have to worry about. Its a promisea promise to engineer the highest quality transmissions in the world. These kits provide the correct amount of fluid and spin on external filter for 2001-2019 Duramax diesels using standard Allison transmission pans. Is 2.46 us quarts of oil. Huntsville, AL. These links are affiliate links. That may have some influence on how much fluid you put inside this transmission. The transmission fluid capacity for the Allison 1000 series transmission is 12 quarts (11.4L). | Our Privacy Policy | Web Design by Green Matchbox, Comprehensive 6.6L L5P Duramax Maintenance Guide, Diesel Resource | Your go-to diesel experts, Fluid Capacity & Recommendations for the L5P resource, 5 Convenient Features of the 2020 L5P Duramax, Build Your Next Super Duty 6.7L Powerstroke, 11 Common 6.6 LLY Duramax Problems And How To Fix Them, 2.8L LWN Duramax Specs, Tow Ratings, and Fuel Economy, 3.0L LM2 Duramax Specs, Fuel Economy, and Towing Capacity, 5 Best 6.6L L5P Duramax Performance Upgrades, 6.6L L5P Duramax Specs, Tow Ratings, And Model Year Changes, 6.6L LB7 Duramax Specifications And Information, 6.6L LLY Duramax Specifications & Information, 6.6L LML Duramax Specifications and Information, Comprehensive 2.8L LWN Duramax Maintenance Guide, Comprehensive 6.6L LBZ Duramax Maintenance Guide & Parts List, Comprehensive LML Duramax Service Schedule, LB7 Duramax Maintenance Schedule, Fluid Specs, And Parts, The Ultimate 6.6L LLY Duramax Maintenance Guide & Service Schedule. I have a MD3000MH transmission in my Horizon and drained it via drain plug and removed the filters to replace them. 12 L. Without special equipment it is possible to replace only ATF in the AT pan because of the way automatic transmission in 2009 Chevrolet Silverado 2500 HD has been designed. But there are no guarantees and none are being made here. Download our Allison TES 668 Fluids Brochure, Vehicle Electrification + Environmental Test Center, Supported by our Allison Authorized Service Network. The key to keeping your transmission running at top levels is to make sure to make those fluid changes regularly and on schedule.